Filter
Top Products
Trouble Recovery
70
NOTE:
Consult your Yamaha dealer if the new fuse
immediately blows again.
EMU29520
Power trim and tilt will not operate
If the engine cannot be tilted up or down with
the power trim and tilt/ the power tilt because
of a discharged battery or a failure with the
power trim and tilt unit/the power tilt, the en-
gine can be tilted manually.
1. Loosen the manual valve screw by turn-
ing it counterclockwise until it stops.
2. Put the engine in the desired position,
then tighten the manual valve screw by
turning it clockwise.
EMU29531
Starter will not operate
If the starter mechanism does not operate
(the engine cannot be cranked with the start-
er), the engine can be started with an emer-
gency starter rope.
WARNING
EWM01020
● Use this procedure only in an emergen-
cy and only to return to port for repairs.
● When the emergency starter rope is
used to start the engine, the start-in-
gear protection device does not operate.
Make sure the remote control lever is in
neutral. Otherwise the boat could unex-
pectedly start to move, which could re-
sult in an accident.
● Attach the engine stop switch lanyard to
a secure place on your clothing, or your
arm or leg while operating.
● Do not attach the lanyard to clothing
that could tear loose. Do not route the
cord where it could become entangled,
preventing it from functioning.
● Avoid accidentally pulling the lanyard
during normal operation. Loss of engine
power means the loss of most steering
control. Also, without engine power, the
boat could slow rapidly. This could
cause people and objects in the boat to
be thrown forward.
● Be sure no one is standing behind you
when pulling the starter rope. It could
whip behind you and injure someone.
● An unguarded, rotating flywheel is very
dangerous. Keep loose clothing and
other objects away when starting the en-
gine. Use the emergency starter rope
only as instructed. Do not touch the fly-
wheel or other moving parts when the
engine is running. Do not install the
starter mechanism or top cowling after
the engine is running.
● Do not touch the ignition coil, spark plug
wire, spark plug cap, or other electrical
components when starting or operating
the motor. You could get an electrical
shock.
EMU29561
Emergency starting engine
1. Remove the top cowling.
2. Fuse (10 A)
3. Spare fuse (10 A)
4. Fuse puller
1. Manual valve screw
U60R10E0.book Page 70 Monday, June 21, 2004 9:34 AM