Graco A-25 Outboard Motor User Manual


 
2 3A1569B
Contents
Proportioner Models . . . . . . . . . . . . . . . . . . . . . . . . 3
Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Related Manuals . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Important Two-Component Material Information . 7
Isocyanate Conditions . . . . . . . . . . . . . . . . . . . . . 7
Material Self-ignition . . . . . . . . . . . . . . . . . . . . . . 7
Keep Components A and B Separate . . . . . . . . . 7
Moisture Sensitivity of Isocyanates . . . . . . . . . . . 7
Foam Resins with 245 fa Blowing Agents . . . . . . 7
Changing Materials . . . . . . . . . . . . . . . . . . . . . . . 8
Typical Installation, without Circulation . . . . . . . . 9
Typical Installation, with Circulation . . . . . . . . . . 10
Component Identification . . . . . . . . . . . . . . . . . . . 11
Control Panel . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Temperature Controls and Indicators . . . . . . . . 13
Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Locate Reactor A-25 . . . . . . . . . . . . . . . . . . . . . 15
Determine Power Source . . . . . . . . . . . . . . . . . 15
Electrical Requirements . . . . . . . . . . . . . . . . . . 15
Configure to Supply Power . . . . . . . . . . . . . . . . 16
Ground System . . . . . . . . . . . . . . . . . . . . . . . . . 18
Iso Pump Lubrication System Setup . . . . . . . . . 18
Fluid Supply Connections . . . . . . . . . . . . . . . . . 18
Air Supply Connection . . . . . . . . . . . . . . . . . . . 18
Recirculation / Pressure Relief Lines . . . . . . . . 19
Install Fluid Temperature Sensor (FTS) . . . . . . 19
Connect Heated Hose . . . . . . . . . . . . . . . . . . . . 19
Close Gun Fluid Inlet Valves A and B . . . . . . . . 20
Connect Whip Hose to Gun or Gun Fluid Manifold
20
Initial Startup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Pressure Check Hose . . . . . . . . . . . . . . . . . . . . 21
Set Temperatures . . . . . . . . . . . . . . . . . . . . . . . 22
Supply Wet-Cups with Throat Seal Liquid . . . . . 23
Spraying . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Spray Adjustments . . . . . . . . . . . . . . . . . . . . . . 25
Park . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Pressure Relief Procedure . . . . . . . . . . . . . . . . . . 26
Shutdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Flushing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Daily Start-up Procedure . . . . . . . . . . . . . . . . . . 28
Fluid Circulation . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Circulation Through Reactor . . . . . . . . . . . . . . . 30
Circulation Through Gun Manifold . . . . . . . . . . . 31
DataTrak Controls and Indicators . . . . . . . . . . . . . 32
DataTrak Operation . . . . . . . . . . . . . . . . . . . . . . . . 33
Setup Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Run Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
Diagnostic Codes . . . . . . . . . . . . . . . . . . . . . . . . . . 35
Temperature Control Diagnostic Codes . . . . . . . 35
DataTrak Diagnostic Codes . . . . . . . . . . . . . . . . 35
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Technical Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Graco Standard Warranty . . . . . . . . . . . . . . . . . . . 38